Maqola

Mitigating fines migration in low salinity water flooding of clay rich sandstones using TiO2 Saponin Zr nanocomposites

Yifan LiSchool of Mechanical and Electrical Engineering, GongQing Institute of Science and Technology, Jiujiang, 332020, Jiangxi, China. [email protected]Farag M. A. AltalbawyDepartment of Chemistry, University College of Duba, University of Tabuk, Tabuk, Saudi ArabiaNikunj RachchhDepartment of Mechanical Engineering, Faculty of Engineering and Technology, Marwadi University Research Center, Marwadi University, Rajkot, Gujarat, 360003, IndiaThiagarajan RamachandranDepartment of Mechanical Engineering, School of Engineering and Technology, JAIN (Deemed to be University), Bangalore, Karnataka, IndiaAman ShankhyanCentre for Research Impact and Outcome, Chitkara University Institute of Engineering and Technology, Chitkara University, Rajpura, Punjab, 140401, IndiaA. KarthikeyanDepartment of Mechanical Engineering, Sathyabama Institute of Science and Technology, Chennai, Tamil Nadu, IndiaDhirendra Nath ThatoiDepartment of Mechanical Engineering, Siksha 'O' Anusandhan (Deemed to be University), Bhubaneswar, Odisha, 751030, IndiaDeepak GuptaDepartment of Mechanical Engineering, Graphic Era Deemed to be University, Dehradun, Uttarakhand, 248002, IndiaMohammad R.K.M. Al-BadkubiBuilding and Construction Technical Engineering Department, College of Technical Engineering, The Islamic University, Najaf, IraqDilsora AbduvalievaDepartment of Mathematics and Information Technologies, Tashkent State Pedagogical University, Bunyodkor Avenue, 27, 100070, Tashkent, UzbekistanSamim SherzodFaculty of Engineering, Nangarhar University, Nangarhar, Afghanistan. [email protected]Mohammad Mahtab AlamDepartment of Basic Medical Sciences, College of Applied Medical Science, King Khalid University, 61421, Abha, Saudi Arabia

Scientific Reportsjournal2025en

Ochiq kirishOltin

Litsenziya: cc-by-nc-nd

ABI

Annotatsiya

Mitigating formation damage due to fines migration is crucial for maintaining reservoir productivity in enhanced oil recovery (EOR) processes. This research introduces a novel composite, Titanium dioxide nanoparticles coated with Saponin and Zirconium (TiO2@Saponin/Zr(IV)), synthesized via a sol–gel method, to address this challenge, particularly in low salinity water injection scenarios. Characterization through FT-IR confirmed successful functionalization, indicated by the Zr–O band at 480 cm−1 and saponin bands around 1030–1085 cm−1 and 2919–2850 cm−1. Zeta potential measurements showed that in low salinity brine, quartz and kaolinite exhibited highly negative potentials of − 32 mV and − 45 mV, respectively, while TiO2@Saponin/Zr(IV) displayed a positive potential of + 19 mV. Importantly, mixtures of quartz and kaolinite with TiO2@Saponin/Zr(IV) in low salinity conditions resulted in moderated zeta potentials of + 3 mV and − 2 mV, indicating surface charge modulation. Core flooding experiments further validated the composite’s effectiveness. Injecting high salinity water resulted in a minor permeability reduction from 90 to 78 mD, while low salinity water injection caused a drastic drop from 90 to 8 mD. However, with the introduction of 0.5 wt% TiO2@Saponin/Zr(IV) in low salinity water, the permeability reduction was significantly controlled, decreasing from 90 to 85 mD. These quantitative results demonstrate that TiO2@Saponin/Zr(IV) effectively mitigates fines migration by modifying surface charge and preserving permeability, offering a promising solution for formation damage control and enhanced oil recovery.

Hali tarjima qilinmagan

Mavzular

Enhanced Oil Recovery Techniques Concrete and Cement Materials Research Hydrocarbon exploration and reservoir analysis

Identifikatorlar

DOI: 10.1038/s41598-025-03348-2

Iqtiboslar va manbalar

0 ta iqtibos82 ta foydalanilgan manba